Bis leaking rocker cover

[ciaoflyer]

The rocker cover is leaking oil all over my exhaust, it seems to be coming from the nuts that hold it on what is the best way to seal these?

[Hazey-n-Marc]

Mine was doing that, turned out to be the inlet manifold gasket.

[ciaoflyer]

Mine was doing that, turned out to be the inlet manifold gasket.

What do you mean 'inlet manifold gasket'?

[Hazey-n-Marc]

Where the inlet manifold (bit between the bottom of the carb and the block) attaches to the top (right) of the engine, there is a water channel through that. If you take the carb off, it is held on with three (I think) bolts. I had a bit of trouble finding the right replacement gasket, luckily it came off in one piece, so I cleaned up all faces of gasket, block and manifold and very carefully applied red hermetite, seems to be working ok ish.

[Hazey-n-Marc]

Until I took the carb off I thought the water was coming off of the bolts on the rocker as well, I was quite confused by it 

[ciaoflyer]

Cheers, I know the bit you mean and I have a gasket!

[Hazey-n-Marc]

You jammy person!! Good luck with it, you will need a slim 13mm socket on a short extension, if memory serves right, for the internal manifold bolt ( you will know when you see it). I also found that the two carb bolts and washers toward the drivers side need to be removed and replaced with the carb slightly lifted.

Marc

[Hazey-n-Marc]

I would also suggest replacing the water pipe that goes to the inlet manifold, and the heat exchange type thing from the exhaust to the drivers side side vent when you are there. I found the water pipe was well done, due to the heat from the exhaust I suppose

[ciaoflyer]

If it is not the intake manifold I think I may need these as I don't have them.....

http://www.ricambio.co.uk/1330-rocker-cover-fibre-washer--classic-fiat-500-126

[Hazey-n-Marc]

I can't see (please shout me down if I am wrong) how water would be seeping from the rocker cover without some serious problems. I think if that was the case both your oil and water would resemble very cheap and overcooked scotch broth.

[ciaoflyer]

I can't see (please shout me down if I am wrong) how water would be seeping from the rocker cover without some serious problems.

Only oil is leaking from my rocker

[Hazey-n-Marc]

poo! sorry I misread the first post as water . 


 






 

[Hazey-n-Marc]

What a cupid stunt I am!! (slight anti censorship protest )

You should probably ignore most of that

[ciaoflyer]

So don't touch the inlet gasket then.........I did think this was a little odd, thanks for your help though!

[Hazey-n-Marc]

Don't thank me for wasting your time, take the piss instead ( I probably would  )